Section 35 (Rear Axle - With Diagnostics - Lancer Evolution)

• General Information
  • Notes
  • Construction Diagram
• General Specifications
• Service Specifications
• Lubricants
• Sealant
• Rear Axle Diagnosis < Except AYC >
  • Introduction
  • Troubleshooting Strategy
  • Symptom Chart
  • Symptom Procedures
    • INSPECTION PROCEDURE 1: Noise during Wheel Rotation < DRIVESHAFT >
      • Diagnosis
    • INSPECTION PROCEDURE 8: Oil Leakage < DIFFERENTIAL >
      • Diagnosis
• Rear Axle Diagnosis < AYC >
  • Standard Flow Of Diagnostic Troubleshooting
  • Diagnostic Function
    • How To Connect The Scan Tool (M.U.T.-III)
    • How To Read And Erase Diagnostic Trouble Codes
  • Diagnostic Trouble Code Table
  • Inspection Procedure For Diagnosis Code
    • DTC C1619: AYC current value abnormality
      • Notes
      • Operation
      • Function
      • Trouble Judgment
        • Range of check
        • Judgment Criteria
        • Fail-safe, backup function
      • Probable Causes
      • Diagnostic Procedure
    • DTC C161A: AYC direction valve (RH) output error
      • Notes
      • Operation
      • Function
      • Trouble Judgment
        • Range of check
        • Judgment Criteria
        • Fail-safe, backup function
      • Probable Causes
      • Diagnostic Procedure
    • DTC C161B: AYC direction valve (LH) output error
      • Notes
      • Operation
      • Function
      • Trouble Judgment
        • Range of check
        • Judgment Criteria
        • Fail-safe, backup function
      • Probable Causes
      • Diagnostic Procedure
    • DTC C1620: AYC control abnormality
      • Notes
      • Operation
      • Function
      • Trouble Judgment
        • Range of check
        • Judgment Criteria
        • Fail-safe, backup function
      • Probable Causes
      • Diagnostic Procedure
      • Trouble Symptom Chart
  • Symptom Procedures
    • Inspection Procedure 1: Abnormal noise from AYC differential (torque transfer mechanism) during cornering
      • Comments On Trouble Symptom
      • Probable Causes
      • Diagnostic Procedure
  • Data List Reference Table
  • Actuator Test Reference Table
  • Check At AWC-Ecu
• Special Tool
• On-Vehicle Service
  • Rear Axle Total Backlash Check
  • Gear Oil Level Check
    • Differential Mechanism Part
    • Torque Transfer Mechanism Part
  • Gear Oil Replacement
    • Differential Mechanism Part
    • Torque Transfer Mechanism Part
  • Fluid Level Check
    • < When The Scan Tool Is Not Used >
    • < When The Scan Tool Is Used >
  • AYC Bleeding
  • AYC Operation Check
  • Oil Pressure Check
  • Wheel Bearing End Play Check
  • Hub Bolt Replacement
  • AYC Differential Carrier Oil Seal Replacement
    • Differential Mechanism Part
    • Torque Transfer Mechanism Part
• Rear Axle Hub Assembly
  • Removal And Installation
    • Notes
    • Removal Service Points
      • << A >> Rear Driveshaft Nut Removal
      • << B >> Rear Wheel Hub Assembly Removal
    • Installation Service Point
      • >> A << Washer/Rear Driveshaft Nut Installation
  • Inspection
    • Wheel Bearing Rotation Starting Torque And End Play Check
• Knuckle
  • Removal And Installation
    • Notes
    • Removal Service Point
      • << A >> Self-Locking Nut Removal
    • Installation Service Point
      • >> A << Self-Locking Nut Installation
• Driveshaft Assembly
  • Removal And Installation
    • Notes
    • Removal Service Points
      • << A >> Rear Driveshaft Nut Removal
      • << B >> Self-Locking Nut Removal
      • << C >> Rear Driveshaft Assembly Removal
    • Installation Service Points
      • >> A << Rear Driveshaft Assembly Installation
      • >> B << Self-Locking Nut Installation
      • >> C << Washer/Rear Driveshaft Nut Installation
  • Disassembly And Assembly
  • Lubrication Points
    • Notes
    • Disassembly Service Points
      • << A >> ETJ Case Removal
      • << B >> ETJ Boot Removal
    • Assembly Service Points
      • >> A << ETJ Boot Installation
      • >> B << Spider Assembly/ETJ Case Installation
      • >> C << ETJ Boot Band (Small)/ETJ Boot Band (Large) Installation
  • EBJ Boot Replacement
• Differential Carrier Assembly
  • Removal And Installation
    • Notes
    • Removal Service Point
      • << A >> Propeller Shaft Disconnection
    • Rear Suspension CROSSMEMBER Bushing (For Rear Differential Mount) Replacement
  • Disassembly And Reassembly
    • Notes
    • Lubrication And Adhesive Points
    • Disassembly Service Point
      • << A >> Self-Locking Nut Removal
    • Assembly Service Points
      • >> A << Oil Seal Installation
      • >> B << Oil Seal Installation
      • >> C << Oil Seal Installation
• Hydraulic Unit
  • Removal And Installation
    • Notes
    • Installation Service Points
      • >> A << Reservoir Hose Assembly Installation
      • >> B << Hydraulic Unit And Hydraulic Unit Bracket B Installation
  • Hydraulic Unit Disposal