Section 188 (Hybrid Control System - General Information (PHEV))

• General Safety Information & Caution
  • Safety Precaution
    • Precautions to take before servicing high voltage system
    • Personal Protective Equipment
    • Personal Protective Equipment Inspection
    • Precautions to take when handling power cable
    • Precautions to take when handling (high voltage battery)
    • Precautions in case of fire on (high voltage battery) system
    • Precautions in case of (high voltage battery) gas or electrolyte leakage
    • Precautions when handling the vehicle after an accident
    • Preparations when servicing the accident vehicle
    • Precautions in case HEV is left unattended for a lengthy period
    • Hybrid Vehicle Refrigerant Recovery/(Charging Precautions)
• High Voltage Shut-Off Procedures
• High Voltage Battery System Inspection Guide
  • Notes
  • Handling Guide For Storing, Transporting, And Disposing Of High Voltage Battery Systems
  • Voltage Check
  • Take Insulation Actions For Parts That May Short Circuit
• Inspection Mode Procedures
  • Procedure For Entering Engine Forced Activation Mode
• Troubleshooting
  • Basic Troubleshooting
    • Basic Inspection Procedure
    • Connector Inspection Procedure
    • Wire Harness Inspection Procedure
    • Electrical Circuit Inspection Procedure
• Specifications
  • Specification
    • Hybrid Control System
      • Hybrid Power Control Unit (HPCU)
      • Brake Switch
      • Clutch Pressure Sensor (CPS)
      • DC Fuse
    • High Voltage Battery System
      • Battery Pack Assembly
      • Power Relay Assembly (PRA)
    • High Voltage Battery Control System
      • Safety Plug
      • Main Fuse
      • Main Relay (+)/(-)
      • Pre Charge Relay
      • Pre-Charge Resistor
      • OBC Fuse
      • OPU Fuse
      • Battery Current Sensor
      • Battery Temperature & Air Inlet Temperature Sensor [Main high voltage battery pack assembly]
      • Battery Temperature & Air Inlet Temperature Sensor [Sub high voltage battery pack assembly]
      • Cooling Fan
        • Current
        • Duty
        • ON-Board Charger (OBC)
        • Low Voltage DC/DC Converter (LDC) [Inside of HPCU]
  • Tightening Torques
    • Hybrid Control System
    • High Voltage Battery System
    • High Voltage Battery Control System
    • High Voltage Battery Cooling System
    • High Voltage Charging System
    • Low Voltage DC/DC Converter (LDC)
    • Power Cable
• Special Service Tools
  • Notes
  • Personal Protective Equipment
  • Commercial Tool
• Description And Operation
  • Hybrid Electric Vehicle (HEV)
    • Notes
    • [HEV Operation Mode and Power Flow]
    • [Driver Mode]
    • [Warning Lamp]
• Components & Components Location
  • Component Location