Section 1232 (Climate Control System - General Information (Diagnosis And Testing, General Procedures, Removal And Installation, Disassembly And Assembly))
WARNING: This page is about a different car, the 2022 Ford Ranger. However, it is still accessible from the selected car via links, so may be relevant.
- Diagnosis And Testing
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Diagnostic Trouble Code (DTC) Charts
- Symptom Charts
- Pinpoint Tests
- Pinpoint Test A: P0532, P0533
- Pinpoint Test B: P0645
- Pinpoint Test C: B105A:12, B105A:14, B1A61:11, B1A61;15, B1A69:12, B1A69:14
- Pinpoint Test D: B1B71:11, B1B71:15
- Pinpoint Test E: The Temperature Control Is Inoperative Or Does Not Operate Correctly - RH (Right-Hand) Side
- Pinpoint Test F: Unable To Duplicate The Customer Concern And No Diagnostic Trouble Codes (DTCS) Present
- Pinpoint Test G: The Air Inlet Door Is Inoperative
- Pinpoint Test H: Incorrect Or Erratic Direction Of Airflow From Outlets
- Pinpoint Test I: Insufficient, Erratic Or No Heat
- Pinpoint Test J: The A/C (Air Conditioning) Is Inoperative - With No Diagnostic Trouble Codes (DTCS)
- Pinpoint Test K: The A/C (Air Conditioning) Is Always On -- A/C (Air Conditioning) Mode Always Commanded On
- Pinpoint Test L: The Blower Motor Is Inoperative
- Pinpoint Test M: The Blower Motor Does Not Operate Correctly
- Pinpoint Test N: B10B5:11, B10B5:15, B10B6:11, B10B6:15
- Pinpoint Test O: P193E
- Pinpoint Test P: C1B14:11, C1B14:12
- Pinpoint Test Q: Externally Controlled Variable Displacement Compressor (EVDC) Performance Check With Or Without DTC (Diagnostic Trouble Code) P06A0
- Pinpoint Test R: P2600:00, P2601:00, P2602:00, P2603:00
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC)
- General Procedures
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil
- Air Conditioning (A/C) Compressor Leak Detection
- Air Conditioning (A/C) Odor Treatment
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Leak Test Using Forming Gas
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Condenser Core Leak Check
- Electronic Leak Detection
- Evaporator Core Leak Check
- Fluorescent Dye Leak Detection
- Heater Core Leak Check
- Refrigerant Identification Testing
- Refrigerant Oil Adding
- Refrigerant System Tests - 2.3L EcoBoost (201kW/273PS)
- Reset the Outside Air Temperature Sensor Learned Values
- Removal And Installation
- Air Conditioning (A/C) Compressor - 2.3L EcoBoost (201kW/273PS)
- Air Conditioning (A/C) Compressor Inlet Line - 2.3L EcoBoost (201kW/273PS)
- Air Conditioning (A/C) Compressor Outlet Line - 2.3L EcoBoost (201kW/273PS)
- Air Conditioning (A/C) Pressure Transducer - 2.3L EcoBoost (201kW/273PS)
- Air Distribution Door Actuator
- Air Inlet Door Actuator
- Ambient Air Temperature Sensor
- Blower Motor Control Module
- Cabin Air Filter
- Cabin Heater Coolant Pump - 2.3L EcoBoost (201kW/273PS)
- Center Registers
- Climate Control Housing
- Driver Side Footwell Air Discharge Temperature Sensor
- Condenser
- Driver Side Register
- Driver Side Register Air Discharge Temperature Sensor
- Evaporator
- Evaporator Temperature Sensor
- Heater Core
- Heating, Ventilation and Air Conditioning (HVAC) Control Module
- In-Vehicle Temperature and Humidity Sensor
- Passenger Side Register
- Passenger Side Temperature Door Actuator
- Receiver Drier
- Sunload Sensor
- Temperature Door Actuator
- Thermostatic Expansion Valve - 2.3L EcoBoost (201kW/273PS)
- Thermostatic Expansion Valve Manifold and Tube Assembly - 2.3L EcoBoost (201kW/273PS)
- Disassembly And Assembly