Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Toyota >> 2009 >> Matrix Base, Automatic >> Repair and Diagnosis >> Heating, Ventilation & A/C (HVAC) >> HVAC Control Systems >> Heating / Air Conditioning >> Air Inlet Control Servo Motor >> Installation

Air Inlet Control Servo Motor: Installation

  1. INSTALL AIR INLET CONTROL SERVO MOTOR 
    1. Install the air inlet control servo motor with the 2 screws.
      Fig 1: Identifying Air Inlet Control Servo Motor With Screws
      G06015448Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  2. INSTALL BLOWER ASSEMBLY (w/o PTC Heater) (See  INSTALLATION  ) 
  3. INSTALL BLOWER ASSEMBLY (w/ PTC Heater) (See  INSTALLATION  ) 
  4. INSTALL NO. 3 AIR DUCT SUB-ASSEMBLY (See  INSTALLATION  ) 
  5. TEMPORARILY TIGHTEN AIR CONDITIONING UNIT (See  INSTALLATION  ) 
  6. INSTALL INSTRUMENT PANEL REINFORCEMENT ASSEMBLY (See  INSTALLATION  ) 
  7. INSTALL AIR CONDITIONING UNIT (See  INSTALLATION  ) 
  8. INSTALL INSTRUMENT PANEL BRACE SUB-ASSEMBLY (See  INSTALLATION  ) 
  9. INSTALL THEFT WARNING ECU ASSEMBLY  (See INSTALLATION )
  10. INSTALL CENTER INSTRUMENT PANEL TO COWL BRACE (See  INSTALLATION  ) 
  11. INSTALL NO. 1 AIR DUCT SUB-ASSEMBLY (See  INSTALLATION  ) 
  12. INSTALL CENTER INSTRUMENT PANEL REGISTER CONNECTOR ASSEMBLY (See  INSTALLATION  ) 
  13. INSTALL REAR NO. 1 AIR DUCT (w/ Rear Air Duct) (See  INSTALLATION  ) 
  14. INSTALL REAR NO. 2 AIR DUCT (w/ Rear Air Duct)  (See INSTALLATION )
  15. INSTALL REAR NO. 3 AIR DUCT (w/ Rear Air Duct) (See  INSTALLATION  ) 
  16. INSTALL AIR CONDITIONING AMPLIFIER ASSEMBLY (See  INSTALLATION  ) 
  17. INSTALL POWER STEERING ECU ASSEMBLY  (See INSTALLATION )
  18. INSTALL STEERING POST ASSEMBLY  (See INSTALLATION )
  19. TURN FRONT WHEELS TO FACE STRAIGHT AHEAD 
  20. CONNECT NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY (for 2WD)  (See INSTALLATION )
  21. CONNECT NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY (for 4WD)  (See INSTALLATION )
  22. INSTALL STOP LIGHT SWITCH ASSEMBLY  (See INSTALLATION )
  23. INSTALL NO. 2 AIR DUCT SUB-ASSEMBLY  (See INSTALLATION )
  24. INSTALL INSTRUMENT PANEL SUB REINFORCEMENT  (See INSTALLATION )
  25. INSTALL COLUMN HOLE COVER SILENCER SHEET  (See INSTALLATION )
  26. INSTALL TRANSPONDER KEY AMPLIFIER (w/ Engine Immobilizer System)  (See INSTALLATION )
  27. INSTALL LOWER INSTRUMENT PANEL SUB-ASSEMBLY  (See INSTALLATION )
  28. INSTALL RADIO WIRE SUB-ASSEMBLY  (See INSTALLATION )
  29. INSTALL TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY  (See INSTALLATION )
  30. INSTALL UPPER STEERING COLUMN COVER  (See INSTALLATION )
  31. INSTALL LOWER STEERING COLUMN COVER  (See INSTALLATION )
  32. CONNECT SHIFT LEVER ASSEMBLY (for Manual Transaxle)  (See INSTALLATION )
  33. CONNECT SHIFT LEVER ASSEMBLY (for Automatic Transaxle)  (See INSTALLATION )
  34. INSTALL COWL SIDE TRIM BOARD LH  (See INSTALLATION )
  35. INSTALL FRONT DOOR SCUFF PLATE LH  (See INSTALLATION )
  36. INSTALL NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY (w/ Instrument Panel Under Cover)  (See INSTALLATION )
  37. INSTALL COWL SIDE TRIM BOARD RH  (See INSTALLATION )
  38. INSTALL FRONT DOOR SCUFF PLATE RH  (See INSTALLATION )
  39. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY  (See INSTALLATION )
  40. INSTALL NO. 1 SWITCH HOLE BASE  (See INSTALLATION )
  41. INSTALL LOWER CENTER INSTRUMENT PANEL FINISH PANEL (for Manual Transaxle)  (See INSTALLATION )
  42. INSTALL LOWER CENTER INSTRUMENT PANEL FINISH PANEL (for Automatic Transaxle)  (See INSTALLATION )
  43. INSTALL FRONT NO. 1 CONSOLE BOX INSERT  (See INSTALLATION )
  44. INSTALL FRONT NO. 2 CONSOLE BOX INSERT  (See INSTALLATION )
  45. INSTALL FRONT CONSOLE BOX ASSEMBLY (for 2WD)  (See INSTALLATION )
  46. INSTALL FRONT CONSOLE BOX ASSEMBLY (for 4WD)  (See INSTALLATION )
  47. INSTALL CONSOLE BOX CARPET 
  48. INSTALL NO. 2 SWITCH HOLE BASE  (See INSTALLATION )
  49. INSTALL FRONT UPPER CONSOLE BOX  (See INSTALLATION )
  50. INSTALL AIR CONDITIONING PANEL ASSEMBLY (See  INSTALLATION  ) 
  51. INSTALL NAVIGATION ANTENNA CORD SUB-ASSEMBLY (w/ Navigation System)  (See )
  52. INSTALL RADIO RECEIVER ASSEMBLY WITH BRACKET (w/o Navigation System)  (See INSTALLATION )
  53. INSTALL NAVIGATION RECEIVER ASSEMBLY WITH BRACKET (w/ Navigation System)  (See INSTALLATION )
  54. INSTALL UPPER INSTRUMENT PANEL SUB-ASSEMBLY  (See INSTALLATION )
  55. CONNECT INSTRUMENT PANEL WIRE ASSEMBLY  (See INSTALLATION )
  56. INSTALL NO. 1 INSTRUMENT PANEL BOX DOOR SUB-ASSEMBLY  (See INSTALLATION )
  57. INSTALL GLOVE COMPARTMENT DOOR ASSEMBLY  (See INSTALLATION )
  58. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY (for Manual Transaxle)  (See INSTALLATION )
  59. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY (for Automatic Transaxle)  (See INSTALLATION )
  60. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle)  (See INSTALLATION )
  61. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for Automatic Transaxle)  (See INSTALLATION )
  62. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL ASSEMBLY  (See INSTALLATION )
  63. INSTALL FRONT PILLAR GARNISH LH (w/o Curtain Shield Airbag)  (See INSTALLATION )
  64. INSTALL FRONT PILLAR GARNISH LH (w/ Curtain Shield Airbag)  (See INSTALLATION )
  65. CONNECT FRONT DOOR OPENING TRIM WEATHERSTRIP LH  (See INSTALLATION )
  66. INSTALL FRONT PILLAR GARNISH RH (w/o Curtain Shield Airbag)  (See INSTALLATION )
  67. INSTALL FRONT PILLAR GARNISH RH (w/ Curtain Shield Airbag)  (See INSTALLATION )
  68. CONNECT FRONT DOOR OPENING TRIM WEATHERSTRIP RH  (See INSTALLATION )
  69. INSTALL COMBINATION METER ASSEMBLY  (See DISASSEMBLY )
  70. INSTALL METER HOOD SUB-ASSEMBLY  (See INSTALLATION )
  71. INSTALL INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY  (See INSTALLATION )
  72. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY  (See INSTALLATION )
  73. TURN FRONT WHEELS TO FACE STRAIGHT AHEAD 
  74. ADJUST SPIRAL CABLE  (See INSTALLATION )
  75. INSTALL STEERING WHEEL ASSEMBLY  (See INSTALLATION )
  76. INSTALL STEERING PAD  (See INSTALLATION )
  77. INSTALL LOWER NO. 3 STEERING WHEEL COVER  (See INSTALLATION )
  78. INSTALL LOWER NO. 2 STEERING WHEEL COVER  (See INSTALLATION )
  79. INSPECT STEERING WHEEL CENTER POINT 
  80. INSTALL HEATER OUTLET WATER HOSE (See  INSTALLATION  ) 
  81. INSTALL HEATER INLET WATER HOSE (See  INSTALLATION  ) 
  82. INSTALL LIQUID PIPE SUB-ASSEMBLY (See  INSTALLATION  ) 
  83. INSTALL SUCTION PIPE SUB-ASSEMBLY (See  INSTALLATION  ) 
  84. CHARGE WITH REFRIGERANT (See  REFRIGERANT  ) 
  85. ADD ENGINE COOLANT (for 2AZ-FE)  (See COOLANT )
  86. ADD ENGINE COOLANT (for 2ZR-FE)  (See COOLANT )
  87. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL 
  88. INSPECT FOR COOLANT LEAK (for 2AZ-FE)  (See COOLING SYSTEM )
  89. INSPECT FOR COOLANT LEAK (for 2ZR-FE)  (See COOLING SYSTEM )
  90. INSPECT STEERING PAD  (See INSTALLATION )
  91. INSPECT SRS WARNING LIGHT 

    (See DIAGNOSIS SYSTEM )

  92. WARM UP ENGINE (See  REPLACEMENT  ) 
  93. INSPECT FOR REFRIGERANT LEAK (See  ON-VEHICLE INSPECTION   ) 
scientia non olet · About Mike's Workshop Manuals