Manual Transmission
- Specifications
- Fastener Tightening Specifications
- Sealers, Adhesives & Lubricants
- Lubrication Specifications
- Transmission Clearance Specifications
- 1st & 2nd Gear Synchronizer Retaining Ring Specifications
- 3rd & 4th Gear Synchronizer Retaining Ring Specifications
- 5th Gear Synchronizer Retaining Ring Specifications
- Countershaft Front Bearing Retaining Ring Specifications
- Input Shaft Bearing Retaining Ring Specifications
- Fifth Gear Retaining Ring Specifications
- Component Resistance
- Schematic & Routing Diagrams
- Visual Identification
- Diagnostic Information & Procedures
- Diagnostic Code Index
- Diagnostic Starting Point - Manual Transmission
- DTC P0501
- DTC P0502
- DTC P0502 or P0503
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Procedures
- DTC P0806
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Procedures
- DTC P0807 or P0808
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Procedures
- DTC P080A
- Clutch Pedal Position Sensor Learn
- Symptoms - Manual Transmission
- Transmission Shifts Hard
- Transmission Gear Clash When Shifting Gears
- Transmission Noisy
- Transmission Does Not Shift into One Gear
- Transmission Jumps Out of Gear
- Transmission Locked in One Gear
- Transmission Clunk on Acceleration or Deceleration
- Transmission Fluid Leak Diagnosis
- Repair Instructions - On Vehicle
- Transmission Fluid Replacement
- Transmission Control Boot Replacement
- Control Lever and/or Boot Replacement (SKY)
- Control Lever and/or Boot Replacement (Solstice)
- Vehicle Speed Sensor Replacement
- Transmission Mount Replacement (Z0K)
- Transmission Input Shaft Bearing Retainer Replacement
- Transmission Input Shaft Seal Replacement
- Transmission Housing Oil Seal Replacement - Rear
- Backup Lamp Switch Replacement
- Transmission Replacement (With Z0K)
- Transmission Replacement (Without Z0K)
- Repair Instructions - Off Vehicle
- Transmission Disassemble
- Output Shaft Disassemble (Solstice)
- Input Shaft Disassemble
- Counter Gear Shaft Disassemble
- Shift Control Housing Disassemble (Solstice)
- Transmission Case Disassemble
- Transmission Extension Disassemble (Solstice)
- Synchronizers Disassemble
- Gears & Shafts Cleaning & Inspection
- Bearings & Spacers Cleaning & Inspection
- Synchronizers Cleaning & Inspection
- Shift Shaft & Shift Fork Cleaning & Inspection
- Transmission Case Cleaning & Inspection
- Shift Control Housing Cleaning & Inspection (Solstice)
- Synchronizers Assemble
- Transmission Extension Assemble
- Transmission Case Assemble
- Shift Control Housing Assemble
- Counter Gear Shaft Assemble
- Input Shaft Assemble
- Output Shaft Assemble (Solstice)
- Transmission Assemble
- Description & Operation
- Special Tools & Equipment