Section 162 (Wiring Systems - Specifications, Component Views And Connector End Views)
WARNING: This page is about a different car, the 2006 Saturn Ion Red Line, 2006 Saturn Ion 3, and 2006 Saturn Ion 2. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Diagnostic Information and Procedures
- Passenger Car Zoning
- Electrical Symbols
- General Electrical Diagnosis Procedures
- Checking Aftermarket Accessories
- Circuit Testing
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Testing for Intermittent Conditions and Poor Connections
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Wiring Repairs
- Repairing Damaged Wire Insulation
- GMLAN Wiring Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- SIR/SRS Wiring Repairs
- Connector Repairs
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- AFL/EPC Connectors
- Bosch Connectors (BSK)
- Bosch Connectors (2.8 JPT)
- Bosch Connectors (0.64)
- Bosch Connectors (ECM)
- Delphi Connectors (Pull to Seat Connectors)
- Delphi Connectors (Push to Seat Connectors)
- Delphi Connectors (Micro-Pack 100W Connectors)
- Delphi Connectors (Micro .64 Connectors)
- Delphi Connectors 12-Way
- FCI Connectors
- JST Connectors
- Kostal Connectors
- Molex Connectors
- Sumitomo Connectors
- Tyco/AMP Connectors (43-Way)
- Tyco/AMP Connectors (Door Module)
- Yazaki Connectors (16-Way)
- Schematic and Routing Diagrams
- Component Locator
- Master Electrical Component List
- Power and Grounding Component Views
- Electrical Center Identification Views
- Fuse Block - Underhood Label (2.2L, 2.4L)
- Fuse Block - Underhood Top View (2.2L, 2.4L)
- Fuse Block - Underhood Bottom View (2.2L, 2.4L)
- Fuse Block - Underhood C1 (2.2L, 2.4L)
- Fuse Block - Underhood C2 (2.2L, 2.4L)
- Fuse Block - Underhood C3 (2.2L, 2.4L)
- Fuse Block - Underhood Label (2.0L)
- Fuse Block - Underhood Top View (2.0L)
- Fuse Block - Underhood Bottom View (2.0L)
- Fuse Block - Underhood C1 (2.0L)
- Fuse Block - Underhood C2 (2.0L)
- Fuse Block - Underhood C3 (2.0L)
- Body Control Module (BCM) Label
- Body Control Module (BCM) Top View
- Body Control Module (BCM) Bottom View
- Body Control Module (BCM) C1
- Body Control Module (BCM) C2
- Body Control Module (BCM) C3
- Body Control Module (BCM) C4
- Body Control Module (BCM) C5 (UE1 or U2K)
- Power and Grounding Connector End Views
- Inline Harness Connector End Views
- Repair Instructions
- Special Tools and Equipment