Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Saturn >> 2004 >> Vue Red Line, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 230 (Supplemental Inflatable Restraint System) >> Repair Instructions >> Inflatable Restraint Steering Wheel Module Coil Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2005 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    NOTE: The new SIR coil assembly will be centered. Improper alignment of the SIR coil assembly may damage the unit, causing an inflatable restraint malfunction.
  1. Place the front wheels in the straight forward position with the steering wheel centered.
  2. Disable the SIR system. Refer to SIR Disabling and Enabling Zone 3 .
  3. Remove the inflatable restraint steering wheel module. Refer to Inflatable Restraint Steering Wheel Module Replacement .
  4. Remove the steering wheel. Refer to Steering Wheel Replacement in Steering Wheel and Column.
  5. Remove the steering column covers. Refer to Steering Column Trim Covers Replacement in Steering Wheel and Column.
  6. Release the SIR coil harness clips from the bracket below the column.
  7. Disconnect both the SIR coil and horn/cruise connectors.
    Fig 1: Removing & Installing Inflatable Restraint Steering Wheel Module Coil Connectors
    GM890633Courtesy of GENERAL MOTORS CORP.
  8. Using a small flat-bladed tool, carefully pry the retaining tabs away from the SIR coil assembly and slide the SIR coil assembly off the steering column.
scientia non olet · About Mike's Workshop Manuals