AUTO HVAC Torque Specifications
AUTO HVAC TORQUE SPECIFICATIONS
| Application | Ft. Lbs. (N.m) | |
|---|---|---|
| Compressor Mounting Bolts | ||
| 2.2L | 17 (22) | |
| 3.0L | 15 (20) | |
| Condenser Hose-To-Condenser Block Bolt | 15 (20) | |
| Condenser Hose-To-Condenser Block Fitting Bolt | 15 (20) | |
| Discharge Hose-To-Compressor Bolt | 12 (16) | |
| Discharge Hose-To-Condenser Block Bolt | 15 (20) | |
| Instrument Panel Attachment Screws | 15 (20) | |
| Instrument Panel Beam Inner Studs | 15 (20) | |
| Instrument Panel Beam-To-Steering Column Brace Nuts | 15 (20) | |
| Instrument Panel Bracket Nuts | 15 (20) | |
| Instrument Panel Bracket-To-Floor Panel Nuts | 15 (20) | |
| Rear Shoulder Belt-To-C-Pillar | 26 (35) | |
| Seat Attachment Nuts | 19 (25) | |
| Shoulder Belt-To-Seat Frame Bolts | 26 (35) | |
| Suction Pipe-To-Compressor Bolt | 12 (16) | |
| INCH Lbs. (N.m) | ||
| Air Conditioner Compressor Clutch Coil Screws | 44 (5) | |
| Air Conditioner Compressor Clutch Plate Bolt | 106 (12) | |
| Air Conditioner Outlet-To-Instrument Panel Screws | 22 (2.5) | |
| Air Conditioner Refrigerant Pressure Sensor | 62 (7) | |
| Ambient Air Temperature Sensor Fastener | 35 (4) | |
| Audio System Amplifier-To-Instrument Panel Beam Screws | 89 (10) | |
| Blower Motor Control Module | 27 (3) | |
| Blower Motor Housing Screws | 9 (1) | |
| Blower Motor Resistor Card Screws | 9 (1) | |
| Blower Motor Resistor Screws | 9 (1) | |
| Cluster Trim Plate-To-Instrument Panel Cluster Screws | 22 (2.2) | |
| Condensate Drain Tube Bolt | 31 (3.5) | |
| Condenser Block-To-Radiator End Tank Bolt | 44 (5) | |
| Condenser Hose Clamp-To-Condenser Screws | 53 (6) | |
| Condenser-To-Radiator Bolts | 44 (5) | |
| Console Fasteners | 22 (2.5) | |
| Control Head-To-Instrument Panel Screws | 22 (2.5) | |
| Discharge Hose Clamp-To-Cradle Screws | 44 (5) | |
| Evaporator Core Service Door-To-HVAC Module Screws | 9 (1) | |
| Evaporator Hose Assembly Clamp-To-Horn Bracket Nut | 89 (10) | |
| Evaporator Hose Assembly Clamps | 44 (5) | |
| Evaporator Hose Assembly-To-Condenser Hose Nut | 106 (12) | |
| Evaporator Hose Assembly-To-TXV Bolts | 62 (7) | |
| Evaporator Hose Assembly-To-Suction Pipe Nut | 106 (12) | |
| Fan Housing-To-Blower Motor Housing Screws | 9 (1) | |
| Filter Housing Screws | 31 (3.5) | |
| Filter Housing-To-HVAC Module Screws | 31 (3.5) | |
| Front of Dash Screen-To-Front of Dash Screws | 9 (1) | |
| HVAC Center Duct-To-HVAC Module Screws | 9 (1) | |
| HVAC Control Module-To-Instrument Panel Screws | 22 (2.5) | |
| HVAC Module Duct Screws | 9 (1) | |
| HVAC Module Screws | 9 (1) | |
| HVAC Module-To-Front Of Dash Bolts | 40 (4.5) | |
| Heater Core Retaining Strap Screw | 9 (1) | |
| Heater Primary Lever Screws | 9 (1) | |
| Instrument Cluster-To-Instrument Panel Housing Screws | 22 (2.3) | |
| Instrument Panel Beam Outer Bolts | 62 (7) | |
| Instrument Panel Cluster Trim Plate-To-Instrument Panel Housing Fasteners | 22 (2.5) | |
| Instrument Panel-To-Radio Screws | 22 (2.5) | |
| Lower Fan Shroud Retaining Nuts | 44 (5) | |
| Mode Actuator Screws | 9 (1) | |
| Nut to Harness Clip | 53 (6) | |
| Pressure Relief Valve-To-Compressor | 106 (12) | |
| Radio-To-Instrument Panel Screws | 22 (2.5) | |
| Receiver Dehydrator Block Bolts | 27 (3) | |
| Receiver Dehydrator Clamp Bolt | 44 (5) | |
| Recirculation Actuator Bracket-To-HVAC Module Screws | 9 (1) | |
| Splash Shield Screws | 44 (5) | |
| TXV-To-Evaporator Core Block Bolts | 62 (7) | |
| Valve Assembly-To-Service Port Base | 106 (12) | |
| Vent Primary Lever Screws | 9 (1) | |
| Wiper Arm Assembly Nuts | 106 (12) | |
| Wiper Module Bolts | 44 (5) | |