Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Pontiac >> 2006 >> Grand Prix Base >> Repair and Diagnosis >> Body & Frame >> Windows >> Door System, Mirror System & Window System >> Repair Instructions >> Lock Replacement - Front Door >> Removal Procedure

Removal Procedure

IMPORTANT: Do not attempt repairs in order to correct lock discrepancies. Replace the lock.
  1. Remove the front door trim panel. Refer to Trim Panel Replacement - Side Front Door .
  2. Remove the front door water deflector. Refer to Water Deflector Replacement - Front Door .
    3. Fig 1: Identifying Lock Rod Locations
    GM800969Courtesy of GENERAL MOTORS CORP.
  3. Open the outside handle rod to lock clip located on the door lock.

    The outside handle rods should be loose from the lock.

  4. Remove the lock cylinder rod from the outside door handle. Refer to Lock Cylinder Replacement - Door .
  5. Remove the inside door handle. Refer to Door Handle Replacement - Front Inside .
    6. Fig 2: Identifying Door Lock Components
    GM315760Courtesy of GENERAL MOTORS CORP.
  6. Remove the screws (1, 3, 2) from door lock.
  7. Remove the door lock and rods through the access hole in the door inner panel.
    8. Fig 3: View Of Electrical Connector & Power Window Motor
    GM800438Courtesy of GENERAL MOTORS CORP.
  8. Disconnect the electrical connector (2) from the lock by pulling out on the tab (1).
  9. Remove the rods from the door lock.
scientia non olet · About Mike's Workshop Manuals