Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Mitsubishi >> 2004 >> Lancer Evolution >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 56 (General - SPORTBACK) >> Scheduled Maintenance Table >> Scheduled Maintenance Service For Emission Control And Proper Vehicle Performance

Scheduled Maintenance Service For Emission Control And Proper Vehicle Performance

WARNING: This page is about a different variant/trim than selected.

Inspection and service should be performed any time if a malfunction is observed or suspected.

SCHEDULED MAINTENANCE

NO. EMISSION CONTROL SYSTEM MAINTENANCE SERVICE INTERVALS KILOMETERS IN THOUSANDS 24 48 72 96 120 144 168 192
MILEAGE IN THOUSANDS 15 30 45 60 75 90 105 120
MONTHS 12 24 36 48 60 72 84 96
1 Fuel system (tank, pipe line and connection, and fuel tank filler tube cap) Check for leaks - - - X - - - X
2 Fuel hoses Check condition - X (3) - X - X - X
3 Air cleaner filter Replace - X - X - X - X
4 Evaporative emission control system (except evaporative emission canister) Check for leaks and clogging - - - X - - - X
5 Spark plugs Replace - - - - - - X -
6 Intake and exhaust valve clearance Inspect and adjust If valve noise increases, adjust valve clearance - X - X - X - X
7 Timing belt Replace - - - X (1) - - X (2) X (4)
8 Drive belts (for generator, water pump, power steering pump Check condition - X - X - X - X
9 Exhaust system (connection portion of muffler, muffler pipes and converter heat shields) Check and service - X (3) - X - X - X
(1) For California, Massachusetts, Vermont and Maine, this maintenance is recommended but is not required to maintain the emissions warranty.
(2) This maintenance is not required if previously replaced.
(3) The maintenance is recommended but is not required to maintain the emissions warranty.
(4) In case of replaced at 96,000 km (60,000 miles)/48 months
scientia non olet · About Mike's Workshop Manuals