Technical Service Bulletins

A/C Compressor
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Airbag On-Off Switches (08-37-99)
- Driver Airbag Trim Cover Service (19-009-01)
- Airbag/Clock Spring Service (08-010-01)
- Non-Deployed Airbag Handling Procedures (08-27-00)
Anti-Theft Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Vehicle Start & Stall Or Vehicle No-Start (08-14-99)
Automatic Trans
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
- Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
- High Shift Effort When Shifting Out Of A Gear (21-003-01 REV. A)
- Partial Engagement Of First And/Or Second Gear (21-005-01)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
- Flash Programming Failure Recovery (18-32-98)
- Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Misdiagnosed Leak Detection Pump System (18-01-00)
- Communications Stop Between JTEC Pcm & Generic Scan (08-39-99)
- Catalyst Monitor Doesn't Light Mil Or Set Fault Code (25-02-99)
Axle Shafts
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash Programming Failure Recovery (18-32-98)
Clutch
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
Communication Devices
- Installation Of Radio Transmitting Equipment (08-31-94)
Cooling Fan
- High Engine Temp Due To Extended In-Gear Idling In Hot Ambient Temps (07-03-00)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Differentials & Drive Axles
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
Driveshaft & Universal Joints
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
Electronic Steering
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Electronic Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Engine Control Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Powertrain Control Module Initialization (08-015-05)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- Flash Programming Failure Recovery (18-32-98)
- High Engine Temp Due To Extended In-Gear Idling In Hot Ambient Temps (07-03-00)
- Rough Idle At Cold Temperatures (18-013-01)
- Generic Scan Tool (GST) (18-012-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Communications Stop Between JTEC Pcm & Generic Scan (08-39-99)
- Catalyst Monitor Doesn't Light Mil Or Set Fault Code (25-02-99)
Entertainment Systems
- Recordable Compact Disc Used In Automotive Cd Player (08-11-00)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Windshield - Cowl Water Leaks (23-007-01)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
- Windshield - Cowl Water Leaks (23-007-01)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Fuses & Circuit Breakers
- Wire Splice Repairs (08-06-00)
Gauges & Instrument Panels
- Instrument Cluster Gauge Pointers On Wrong Side (08-33-99)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet (24-012-01)
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Ignition Switch/Steering Lock
- Ignition Lock Cylinder Service (19-02-00 REV. A)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet (24-012-01)
- Driver Airbag Trim Cover Service (19-009-01)
Locking Hubs
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
Manual Steering
- Power Steering Fluid Usage (19-007-01)
Manual Trans
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
- High Shift Effort When Shifting Out Of A Gear (21-003-01 REV. A)
- Partial Engagement Of First And/Or Second Gear (21-005-01)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 4.0L Multiple Cylinder Misfire (09-003-03)
Paint & Coatings
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
Passive Restraints
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Airbag On-Off Switches (08-37-99)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Steering Shimmy (19-003-06)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Steering Control Systems
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
Steering Linkage
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Sun Roof/T-Top/Convertible Top
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
- Hardtop Roof Sag (23-18-00)
Suspension Control Systems
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
System
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- Flash Programming Failure Recovery (18-32-98)
- High Engine Temp Due To Extended In-Gear Idling In Hot Ambient Temps (07-03-00)
- Rough Idle At Cold Temperatures (18-013-01)
- Generic Scan Tool (GST) (18-012-01)
- Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Misdiagnosed Leak Detection Pump System (18-01-00)
- Communications Stop Between JTEC Pcm & Generic Scan (08-39-99)
- Catalyst Monitor Doesn't Light Mil Or Set Fault Code (25-02-99)
Transfer Case
- Gear Train Sound When Manual Trans Is In Neutral (21-002-01)
Transmission Control Systems
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash Programming Failure Recovery (18-32-98)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
Window Motors & Regulators
- Rear Window Lift Glass Seal/Carrier Replacement (23-022-04)
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
- Windshield - Cowl Water Leaks (23-007-01)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wire Splice Repairs (08-06-00)