Technical Service Bulletins
- A/C Compressor
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Contaminated R134A Refrigerant Found On Market For Automotive Air-Conditioning Systems (IB06-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- A/C FREON Blends Warning (SB92-12-003)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- R-12 To R-134A A/C System Conversion - Retrofit Procedures (SB00-12-S004)
- Accessories Control Systems
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Theft Systems
- Automatic Trans
- Automatic Transmission Flushing Procedure (IB02-05-S004)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- DEXRON-IIE A/T And Power Steering Fluid (SB93-14-003)
- A/C FREON Blends Warning (SB92-12-003)
- Km100 Trans Downshift Flare - Servo Return Spring (SB88-05-001)
- A/T Differential Shim Adjustment Gauge Adapter (SB87-14-004)
- Auxiliary Emission Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- SUPRSDES Sb92-03-001:New Prom, O2 TST-Emissions Fail (SB92-03-001)
- Failed State Emission Test - New Prom/O2 Sensor Test (SB91-03-007)
- Revised Emission Control Charts (SB88-03-003)
- 1.5L Eng Intermittent Engine Light On - ECM Ground (SB88-04-004)
- Obstruction Of PCV System/Possible Fire: PCV Valve (SB88-03-002)
- 1.5L Turbo Eng PCV Valve Replacement (SB88-03-002)
- 1.5L Eng Unsatisfactory Eng Performance - Bad Ground (SB87-04-006)
- Surge/Hesitation - Adjustment Guidelines (SB86-14-005)
- Axle Shafts
- Body Interior
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- Recommended Sealants (SB89-14-002)
- 1.5L Eng Loose Ex Manifold Bolts - New Bolt & Torque (SB87-01-001)
- Loose Exhaust Manifold Bolt - Higher Strength Bolt (SB87-01-001)
- Fuel Pump Specifications/Testing (SB86-02-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Cruise Control Systems
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Revised Cruise Control Troubleshooting (SB88-04-001)
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Specified Major Emission-Control Components Defect Warranty Coverage Enhancement (WB07-L004)
- Pcm Reprogramming (IB00-S002)
- SUPRSDES Sb92-03-001:New Prom, O2 TST-Emissions Fail (SB92-03-001)
- Failed State Emission Test - New Prom/O2 Sensor Test (SB91-03-007)
- Revised Emission Control Charts (SB88-03-003)
- 1.5L Eng Intermittent Engine Light On - ECM Ground (SB88-04-004)
- 1.5L Eng Unsatisfactory Eng Performance - Bad Ground (SB87-04-006)
- Surge/Hesitation - Adjustment Guidelines (SB86-14-005)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Electrical Terminal Hardware Kit Available (SB95-14-L004)
- 1.5L Eng Check Engine Lite On - Poor Ground (SB88-04-004)
- 1.5L Eng Intermittent Engine Light On - ECM Ground (SB88-04-004)
- Carpet Slipping/Adhesive Application (SB87-11-009)
- Connector Corrosion - Exposed Relay Cover (SB87-04-005)
- Electrical Connector Corrosion - New Plastic Cover (SB87-04-005)
- Gauges & Instrument Panels
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- Dash Cowl Panel Cracking - Clutch Cable Spacer (SB90-11-001)
- Speedometer/Odometer Replacement Labels (SB89-04-002)
- Carpet Slipping/Adhesive Application (SB87-11-009)
- Inaccurate Temperature Gauge - Instrument Assembly (SB87-04-004)
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- New Sae J2788 Refrigerant Recovery Standard (IB07-12-S004)
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- A/C Refrigerant System Sealer And A/C System Leak Detecting Guidelines (IB04-12-S001)
- Replacement Of The Receiver Drier During Air Conditioning Repair And Service (IB00-12-S002)
- R-12 To R-134A A/C System Conversion/Retrofit Procedures (Supersedes Sb00-12-S002) (SB00-12-S004)
- HVAC System Deodorizing Treatment (SB99-12-S002)
- HVAC System Deodorizing Treatment (SB98-12-L001)
- A/C FREON Blends Warning (SB92-12-003)
- A/C FREON Recovery Caution (SB91-12-002)
- A/C Diagnosis Chart (SB91-12-001)
- R-12 To R-134A A/C System Conversion - Retrofit Procedures (SB00-12-S004)
- Receiver Drier Replacement During Air Conditioning Repair & Service (IB00-12-S002)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Locking Hubs
- Lubrication System
- Engine Oil Usage Testing And Reporting (SB07-01-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Propylene Glycol Based Engine Coolant (SB96-14-L002)
- Propylene Glycol-Based Engine Coolant Warning (SB94-14-005)
- A/C FREON Blends Warning (SB92-12-003)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- Oil Drain Plug Washer Replacement Requirements (SB89-01-011)
- Recommended Sealants (SB89-14-002)
- Turbocharger Operation/Service Precautions (SB87-14-002)
- 1.5L Eng Loose Ex Manifold Bolts - New Bolt & Torque (SB87-01-001)
- Loose Exhaust Manifold Bolt - Higher Strength Bolt (SB87-01-001)
- Fuel Pump Specifications/Testing (SB86-02-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Manual Steering
- Manual Trans
- Mechanical
- Use Of Surface Conditioning Disks (IB05-01-S002)
- Adjustment Of J-45735 Exhaust BACKPRESSURE Gauge (IB03-14-S001)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- Use Of Surface Conditioning Discs (IB00-14-S001)
- Precaution In Installing An ISUZU Oil Filter (IB00-01-S001)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- 1.5L Eng Piston Clearance/OVRSIZE Piston Specs (SB89-01-012)
- Recommended Sealants (SB89-14-002)
- 1.5L Eng Modified Timing Belt Tension Specs (SB87-01-006)
- 1.5L Eng Loose Ex Manifold Bolts - New Bolt & Torque (SB87-01-001)
- Loose Exhaust Manifold Bolt - Higher Strength Bolt (SB87-01-001)
- Fuel Pump Specifications/Testing (SB86-02-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Starter
- Low Voltage Display On IP Gauge, Lights Dim At Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights At Idle, Low Generator Output (IB07-04-S003)
- CALIFORNIA Consent Order On Settlement Of Lawsuit On Batteries (Proposition 65) (IB00-14-S004)
- Battery Testing/Charging (SB88-04-003)
- Fuel Pump Specifications/Testing (SB86-02-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- CALIFORNIA Consent Order-Lawsuit Settlement On Batteries (Proposition 65) (IB00-14-S004)
- Steering Column
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Inspection Of All Related Wiring Harness Connections When Diagnosing Miscellaneous DTC'S, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, Inoperative Air Conditioning Systems, Service Engine Soon Lamps Illuminated, 4WD Lamp Illuminated, Instrument Panel Gauges Inoperative, Cruise Inoperative (IB05-04-S005)
- LOCTITE/PERMATEX Cross-Reference Chart (SB99-14-S001)
- SUPRSDES Sb92-03-001:New Prom, O2 TST-Emissions Fail (SB92-03-001)
- Oil Leak - Rear Oil Seal Diagnosis/Repair (SB92-01-002)
- Failed State Emission Test - New Prom/O2 Sensor Test (SB91-03-007)
- Recommended Sealants (SB89-14-002)
- Revised Emission Control Charts (SB88-03-003)
- 1.5L Eng Intermittent Engine Light On - ECM Ground (SB88-04-004)
- 1.5/1.8L Eng Rough Idle/Surge - Feedback Solenoid (SB88-02-002)
- 1.5L Eng Rough Idle/HESISTATION - Feedback Solenoid (SB88-02-002)
- Obstruction Of PCV System/Possible Fire: PCV Valve (SB88-03-002)
- 1.5L Turbo Eng PCV Valve Replacement (SB88-03-002)
- 1.8/2.2/2.3L Diesel Eng Lacks Power - Fouled Screen (SB87-02-001)
- 1.5L Eng Unsatisfactory Eng Performance - Bad Ground (SB87-04-006)
- Surge/Hesitation - Adjustment Guidelines (SB86-14-005)
- Fuel Pump Specifications/Testing (SB86-02-004)
- Gasoline/Alcohol Fuel Blend Caution/Guidelines (SB84-02-002)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Window Motors & Regulators
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical Terminal Hardware Kit Available (SB95-14-L004)
- 1.5L Eng Check Engine Lite On - Poor Ground (SB88-04-004)
- 1.5L Eng Intermittent Engine Light On - ECM Ground (SB88-04-004)
- Carpet Slipping/Adhesive Application (SB87-11-009)
- Connector Corrosion - Exposed Relay Cover (SB87-04-005)
- Electrical Connector Corrosion - New Plastic Cover (SB87-04-005)