Fastener Specifications
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Evaporative Emission Canister Purge Solenoid Valve Seal |
| Fuel Pressure sensor O-ring |
| High Pressure Fuel Pump Gasket |
| High Pressure Fuel Pump O-ring |
| Primary Fuel Tank Module O-ring |
| Secondary Fuel Tank Module O-ring |
| Throttle Body Seal |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Fuel Feed Intermediate Pipe Fitting | 28 N.m (21 lb ft) |
| Fuel Feed Pipe Fitting | |
|
15 N.m (11 lb ft) |
|
30 N.m (22 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Accelerator Pedal Fastener | 8 N.m (71 lb in) |
| Air Cleaner Assembly Bolt | 6 N.m (53 lb in) |
| Air Cleaner Clamp | 4 N.m (35 lb in) |
| Air Cleaner Fastener | 2 N.m (18 lb in) |
| Camshaft Position Actuator Solenoid Valve Fastener | 10 N.m (89 lb in) |
| Camshaft Position Sensor Fastener | 10 N.m (89 lb in) |
| Crankshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Engine Coolant Temperature Sensor | 20 N.m (15 lb ft) |
| Evaporative Emission (EVAP) Canister-to-Underbody Nut | 9 N.m (80 lb in) |
| Evaporative Emission Canister Purge Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Filler Pipe Fastener | 10 N.m (89 lb in) |
| Front Intake Air Duct Fastener | 10 N.m (89 lb in) |
| Fuel Feed Pipe Bolt | 50 N.m (37 lb ft) |
| Fuel Filler Tube Clamp | 5 N.m (44 lb in) |
| Fuel Injection Fuel Rail Fuel Pressure Sensor | 33 N.m (24 lb ft) |
| Fuel Pipe Shield Bolt | 10 N.m (89 lb in) |
| Fuel Pressure Sensor - Fuel Feed Pipe | 9 N.m (80 lb in) |
| Fuel Pressure Sensor - Fuel Rail | 33 N.m (24 lb ft) |
| Fuel Pump Power Control Module Fastener | 8 N.m (71 lb in) |
| Fuel Rail Fastener | 25 N.m (18 lb ft) |
| Fuel Tank Filler Pipe Clamp | 4 N.m (35 lb in) |
| Fuel Tank Strap-to-Body Nut | 20 N.m (15 lb ft) |
| Heated Oxygen Sensor | 42 N.m (31 lb ft) |
| High Pressure Fuel Pump Retaining Bolt | 15 N.m (11 lb ft) |
| Ignition Coil Bolt | 10 N.m (89 lb in) |
| Knock Sensor Bolt | 25 N.m (18 lb ft) |
| Knock Sensor Heat Shield Bolt - Lower | 58 N.m (43 lb ft) |
| Knock Sensor Heat Shield Bolt - Upper | 10 N.m (89 lb in) |
| Manifold Absolute Pressure Sensor Fastener | 5 N.m (44 lb in) |
| Mass Airflow Sensor Fastener | 3 N.m (27 lb in) |
| Spark Plug | 18 N.m (13 lb ft) |
| Throttle Body Assembly Bolt | 10 N.m (89 lb in) |
| Throttle Inlet Absolute Pressure Sensor Fastener | 4 N.m (35 lb in) |