Section 6 (Climate Control System -- Except Electric)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Description and Operation
- Climate Control System - Vehicles Built From: 05-March-2012, Vehicles With: Electronic Manual Temperature Control (EMTC) - Component Location
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) - Overview
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC) - System Operation and Component Description
- System Diagram
- System Operation
- Component Description
- Heating Ventilation Air Conditioning (HVAC) Control Module - Electronic Manual Temperature Control (EMTC)
- Air Conditioning (AC) Pressure Transducer
- Ambient Air Temperature Sensor
- Evaporator Temperature Sensor
- Defrost-Registor-Footwell Blend Door Actuator
- Temperature Blend Door Actuator
- Air Inlet Blend Door Actuator
- Air Conditioning (AC) Compressor Clutch
- Internally Controlled Variable Displacement Air Conditioning (A/C) Compressor
- Air Conditioning (AC) Condenser
- Evaporator
- Thermostatic Expansion Valve (TXV)
- Receiver-Drier Element
- Service Gauge Port Valves
- Blend Door Actuator - Defrost-Registor-Footwell Door
- Blend Door Actuator - Air Inlet Door
- Refrigerant System Dye
- Blower Motor Resistor
- Climate Control System - Vehicles Built From: 05-March-2012, Vehicles With: Dual Automatic Temperature Control - Component Location
- Climate Control System - Vehicles With: Dual Automatic Temperature Control - Overview
- Climate Control System - Vehicles With: Dual Automatic Temperature Control - System Operation and Component Description
- System Diagram
- System Operation
- Component Description
- Heating Ventilation Air Conditioning (HVAC) Control Module - Dual Automatic Temperature Control (DATC)
- Air Conditioning (AC) Pressure Transducer
- In-Vehicle Temperature and Humidity Sensor
- Ambient Air Temperature Sensor
- Autolamp-Sunload Sensor
- Evaporator Temperature Sensor
- Blower Motor Speed Control
- Air Conditioning (AC) Compressor Clutch
- Internally Controlled Variable Displacement Air Conditioning (A/C) Compressor
- Air Conditioning (AC) Condenser
- Evaporator
- Thermostatic Expansion Valve (TXV)
- Receiver-Drier
- Service Gauge Port Valves
- Blend Door Actuator - Registor-Footwell Door
- Blend Door Actuator - Defrost Door
- Blend Door Actuator - Air Inlet Door
- Temperature Blend Door Actuator - Driver Side
- Temperature Blend Door Actuator - Passenger Side
- Refrigerant System Dye
- Climate Control System - Vehicles Built Up To: 05-March-2012, Vehicles With: Electronic Manual Temperature Control (EMTC) - Component Location
- Climate Control System - Vehicles Built Up To: 05-March-2012, Vehicles With: Dual Automatic Temperature Control - Component Location
- Diagnosis and Testing
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC)
- DTC Chart: Powertrain Control Module (PCM)
- DTC Chart: Body Control Module (BCM)
- Symptom Chart(s)
- Symptom Chart: Noise, Vibration and Harshness (NVH)
- Diagnostic Routine(s)
- Notes
- P0532:00 P0533:00
- P0645:00
- Climate Control System Functional Test
- The Air Inlet Door Is Inoperative
- Incorrect or Erratic Direction of Airflow From Outlets
- Insufficient, Erratic or No Heat
- The Air Conditioning (AC) Is Inoperative
- The Air Conditioning (AC) Is Always On
- The Air Conditioning (AC) Is Always On - AC Mode Always Commanded On
- The Temperature Control is inoperative or Does Not Operate Correctly
- The Blower Motor Is Inoperative
- The Blower Motor Does Not Operate Correctly
- B101E:23
- B1B71:21, B1B71:22, B1B71:2F
- P193E
- Component Test- Heater Core
- Climate Control System - Vehicles With: Dual Automatic Temperature Control
- DTC Chart: Heating Ventilation Air Conditioning (HVAC) Module - Dual Automatic Temperature Control (DATC)
- DTC Chart: Powertrain Control Module (PCM)
- DTC Chart: Body Control Module (BCM)
- Symptom Chart(s)
- Symptom Chart: Noise, Vibration, and Harshness (NVH)
- Diagnostic Routine(s)
- Diagnostic Overview
- Climate Control System Functional Test
- The Air Inlet Door Is Inoperative
- Incorrect or Erratic Direction of Airflow From Outlets
- Insufficient, Erratic or No Heat
- The Air Conditioning (AC) Is Inoperative
- The Air Conditioning (AC) Is Always On
- The Air Conditioning (AC) Is Always On - AC Mode Always Commanded On
- The Temperature Control Is Inoperative or Does Not Operate Correctly - LH
- DTC Fault Trigger Conditions
- The Temperature Control Is Inoperative or Does Not Operate Correctly - RH
- The Blower Motor Is Inoperative
- The Blower Motor Does Not Operate Correctly
- B10B3:00, B10B4:00, B10B5:00, B10B6:00
- B1A61:00, B105A:00
- B1A63:00, B1A64:00
- U3006:16, U3006:17
- U0155:00
- B1B71:21, B1B71:22, B1B71:2F
- P193E
- Component Test- Heater Core
- Heater Core - Plugged
- Heater Core - Pressure Test
- Heater Core - Bench Test
- Component Test- Evaporator or Condenser On-Vehicle Leak Test
- Component Test- Air Conditioning (AC) Compressor External Leak Test
- Climate Control System - Vehicles With: Electronic Manual Temperature Control (EMTC)
- General Procedures
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Air Conditioning (A/C) Odor Treatment
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Electronic Leak Detection
- Fluorescent Dye Leak Detection
- Refrigerant Identification Testing
- Refrigerant Oil Adding
- Refrigerant System Tests
- Removal and Installation
- Blower Motor - Vehicles With: Dual Automatic Temperature Control (DATC)
- Blower Motor - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Heater Core
- Blower Motor Resistor - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Blower Motor Speed Control - Vehicles With: Dual Automatic Temperature Control
- Defrost Vent/Register Door Actuator - Vehicles With: Dual Automatic Temperature Control
- Air Conditioning (A/C) Compressor - 2.0L Duratec-HE
- Air Conditioning (A/C) Compressor - 2.0L EcoBoost
- Evaporator
- Condenser - 2.0L Duratec-HE
- Condenser - 2.0L EcoBoost
- Thermostatic Expansion Valve - 2.0L Duratec-HE, Vehicles Built From: 05-March-2012
- Ambient Air Temperature Sensor
- Center Register Air Discharge Temperature Sensor - Vehicles With: Dual Automatic Temperature Control
- Footwell Air Discharge Temperature Sensor - Vehicles With: Dual Automatic Temperature Control
- Evaporator Temperature Sensor
- Sunload Sensor - Vehicles With: Dual Automatic Temperature Control
- Heater Core and Evaporator Core Housing
- Center Registers
- Driver Side Register
- Passenger Side Register
- Cabin Air Filter
- Temperature Door Actuator - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Driver Side Temperature Door Actuator - Vehicles With: Dual Automatic Temperature Control
- Passenger Side Temperature Door Actuator - Vehicles With: Dual Automatic Temperature Control
- Air Inlet Duct - Vehicles With: Dual Automatic Temperature Control
- Air Inlet Door Actuator - Vehicles With: Dual Automatic Temperature Control
- Heating, Ventilation and Air Conditioning (HVAC) Control Module
- Footwell Vent Door Actuator - Vehicles With: Dual Automatic Temperature Control
- Air Conditioning (A/C) Compressor Inlet Line - 2.0L Duratec-HE, Vehicles Built From: 05-March-2012
- Air Conditioning (A/C) Pressure Transducer
- Air Distribution Door Actuator - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Air Conditioning (A/C) Compressor to Condenser Line - 2.0L Duratec-HE
- Air Conditioning (A/C) Compressor to Condenser Line - 2.0L EcoBoost
- Receiver Drier Element
- Air Conditioning (A/C) Clutch and Air Conditioning (A/C) Clutch Field Coil
- In-Vehicle Temperature and Humidity Sensor - Vehicles With: Dual Automatic Temperature Control
- Thermostatic Expansion Valve Manifold and Tube Assembly - 2.0L Duratec-HE, Vehicles Built From: 05-March-2012
- Thermostatic Expansion Valve Manifold and Tube Assembly - 2.0L Duratec-HE, Vehicles Built Up To: 05-March-2012
- Thermostatic Expansion Valve - 2.0L Duratec-HE, Vehicles Built Up To: 05-March-2012
- Thermostatic Expansion Valve - 2.0L EcoBoost
- Air Inlet Duct - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Air Inlet Door Actuator - Vehicles With: Electronic Manual Temperature Control (EMTC)
- Air Conditioning (A/C) Compressor Inlet Line - 2.0L Duratec-HE, Vehicles Built Up To: 05-March-2012
- Air Conditioning (A/C) Compressor Inlet Line - 2.0L EcoBoost
- Thermostatic Expansion Valve Manifold and Tube Assembly - 2.0L EcoBoost