Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Ford >> 2008 >> Escape Hybrid, AWD >> Repair and Diagnosis >> Engine Performance >> System >> Engine Controls - Reference Values - (Hybrid) >> 2.3L 4V Escape Hybrid >> Typical Diagnostic Reference Values

Typical Diagnostic Reference Values

PCM Sensors / Inputs PCM Pin / PID only Measured/PID Values Units Measured / PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
A/CT B1 2.6-2.9 / 89-102 2.6-2.9 / 89-102 2.6-2.9 / 89-102 2.6-2.9 / 89-102 DCV / DEG F
APP1 B5 4.1 4.1 3.6-4.1 3.6-4.1 DCV
BOO B8 OFF ON OFF OFF ON-OFF
FTP B9 2.6 / 0 2.6 / 0 2.6 / 0 2.6 / 0 DCV / PSI
APP2 B17 1.5 1.5 1.5-2.0 1.5-2.4 DCV
BPO_Hz / BPO B24 2 / NO 6 / YES (I) 2 / NO 2 / NO Hz / YES-NO
APP3 B28 0.9 0.9 0.9-1.3 0.9-1.8 DCV
MAF B32 0 1.21 1.53 1.0 DCV
IAT (G) B39 2.47 / 91.4 2.93 / 73.4 3.57 / 50.0 3.59 / 48.2 DCV / DEG F
FRT (G) E6 2.26 / 102.2 2.15 / 105.8 3.18 / 69.8 3.19 / 69.8 DCV / DEG F
TP2 E8 0.06 0.84 1.27 1.66 DCV
TP1 E19 3.35 4.28 4.11 3.87 DCV
MAP E23 4.01 / 1 / 14.35 1.71 / 58 / 6.09 2.26 / 44 / 8.12 2.91 / 28 / 10.44 DCV / kPa / PSI
FRP E27 2.72 / 38.94 2.74 / 39.29 2.73 / 39.12 2.81 / 40.32 DCV / PSI
O2S11 (C) E30 0 Switching Switching Switching DCV
CHT (G) E33 0.71 / 183.2 0.63 / 190.4 3.42 / 210.2 3.21 / 222.8 DCV / DEG F
O2S12 (D) E42 0.04 0.07 0.77 0.66 DCV
MECT_V T3 2.6 2.6 3.3 3.2 DCV
GTQ_CMD T5 300 / 0 295-300 / (-)5-0 270-300 / (-)22-0 270-300 / (-)22-0 Hz / Lb-ft
MTQ_OUT T7 -0.2 -7.5 0.2 -9.9 Nm
TR_A1 T16 4.29 (H) 4.29 (H) 3.73 (Q) 3.74 (Q) DCV
TR_A2 T28 1.01 (H) 1.01 (H) 3.73 (Q) 3.73 (Q) DCV
DCE T34 ON ON ON ON ON - OFF
TR_A3 T39 0.63 (H) 0.63 (H) 3.35 (Q) 3.35 (Q) DCV
ACCS PID OFF OFF OFF OFF ON-OFF
APP PID 0 0 19.5 0 %
BARO PID 155.8 / 14.24 155.8 / 14.24 156.2 / 14.3 156.6 / 14.36 Hz / PSI
DEL_MOD_V PID 0.06 0.06 0 0.06 DCV
ENG_TQ PID 1047 66.79 297.9 854 Nm
ETC_ATC PID 0.09 3.71 13.77 9.14 DEGREES
FLI PID 86 86 90 95.71 %
HTRCM11 PID 1.64 1.64 1.49 1.49 AMP
HTRCM12 PID 762 762 590 590 mA
KEYST PID RUN RUN RUN RUN KEY POSITION
SHRFT1 PID 0 -0.54 -1.97 -2.02 %
LOAD PID 50.04 19.95 28.29 35.86 %
RPM PID 0 1087 1486 2267 RPM
PCM Actuators / Outputs PCM Pin / PID only Measured / PID Values Units Measured / PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
FP B12 OFF / 75 OFF / 23 OFF / 24 OFF / 25 ON - OFF / %
EVAPCV B13 OFF / 0 OFF / 0 OFF / 0 OFF / 0 ON - OFF / %
PSR B27 ON ON ON ON ON-OFF
FTIV B29 100 0 100 0 %
EVMV B34 OFF / 0 VARYING / 560 VARYING / 0 VARYING / 816 STATUS / mA
HFC B37 OFF ON (B) OFF OFF ON-OFF
LFC B38 OFF ON (B) OFF OFF ON-OFF
HTR11 E49 OFF ON ON ON ON-OFF
HTR12 E50 OFF ON ON ON ON-OFF
MECP T4 ON ON ON ON ON-OFF
ACRDV T22 OFF OFF OFF OFF ON-OFF
HPUMP T23 OFF ON(O) OFF OFF ON-OFF
EGRMDSD PID 1 1 21 23 STEP
ENGRPMA PID 0 1061 1238 2113 RPM
ETC_DSD PID 0 3.7 13.89 9.27 DEGREES
FRP_DSD PID 39.68 39.68 40.07 40.42 PSI
FTP_H2O PID 0.03 -0.06 -0.03 -0.2 in H2O
G_SDN PID NO YES (L) NO NO YES-NO
G_SPEED PID 0 3663 -475 -1036 RPM
GTQ PID 0 0 -0.1 -0.1 Nm
LONGFT1 PID 3.51 3.51 1.95 0 %
MCF PID OFF OF OFF OFF ON - OFF
M_SDN PID NO YES (M) NO NO YES-NO
MTO PID 0 0 0 0 Nm
SPARKADV PID 10 1.25 29.25 32.75 DEGREES
TOT PID 113 113 129.2 129.2 DEG F
Other PCM Pin / PID only Measured / PID Values Units Measured / PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
VPWR B35 / B36 13.75 13.69 13.81 13.81 DCV
VREF B40 / E40 5 5 5 5 DCV

Transaxle Connector C1458A -  

Fig 1: Transaxle Connector C1458A - Terminals
GF0023628Courtesy of FORD MOTOR CO.

Transaxle Connector C1458B -  

Fig 2: Transaxle Connector C1458B - Terminals
GF0023629Courtesy of FORD MOTOR CO.
TCM Inputs TCM Pin / PID only Measured / PID Values Units Measured / PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
ISDN 1 A6 VBAT / CHARGE VBAT / CHARGE VBAT / CHARGE VBAT / CHARGE DCV / CHARGE
ENG_CTO B1 0 1067 (N) 1239 (N) 2105 (N) RPM
I_SDN_2 B7 CHARGE CHARGE CHARGE CHARGE CHARGE
CONTACT PID CLOSED CLOSED CLOSED CLOSED OPEN / CLOSED
GCLTEMP PID 120.2 118.4 140.0 140.0 DEG F
GENMODE PID TORQUE SPEED SPEED SPEED MODE
GTQ_OUT PID 0 -2.9 -12.1 -29.6 Nm
G_INV_V PID 332 335.8 336 336 DCV
G_PHTMP PID 95 95 86 105.8 DEG F
G_SDN_A PID NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN SHUTDOWN - NOT SHUTDOWN
G_SDN_C PID NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN SHUTDOWN - NOT SHUTDOWN
G_SPEED PID 0 3645 -339 -1465 RPM
HVBAT_V PID 330.2 335.2 333.2 336.2 DCV
HV_AMP PID 1.2 A -100 mA 10.4 A 900 mA AMP / mA
MCLTEMP PID 107.6 105.8 147.2 150.8 DEG F
MECT PID 84.2 86 69.8 64.4 DEG F
MTQ_CMD PID 0 -7.4 0.8 -9.9 Nm
M_INV_V PID 330 335 334.1 337.5 DCV
M_PHTMP PID 93.2 98.6 66.2 71.6 DEG F
M_SDN_A PID NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN SHUTDOWN - NOT SHUTDOWN
M_SDN_C PID NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN NOT SHUTDOWN SHUTDOWN - NOT SHUTDOWN
M_SPEED PID 0 0 3869 6981 RPM
PRNDL_T PID PARK (H) PARK (H) DRIVE (Q) DRIVE (Q) SHIFTER POSITION
RPM PID 0 1050-1100 1250-1350 1950-2100 RPM
TQ_DSD PID 0 0 97 254 Nm
VSS PID 0 0 30 55 km/h
TCM Outputs TCM Pin / PID only Measured / PID Values Units Measured / PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
MTQ_OUT B4 0 -8.3 -5.6 -10.9 Nm
GTQ_CMD B9 0 -3.3 -12.4 -29.6 Nm
TCM_CAU PID OFF ON (J) OFF OFF ON / OFF
TCM_HAZ PID OFF ON (K) OFF OFF ON / OFF
Other PCM Pin / PID only Measured / PID Values Units Measured / PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
B+ A12 14.06 13.88 13.94 13.94 DCV
VBAT PID 13.25 13.25 13.69 13.56 DCV
TBCM Outputs PID only PID Values PID
KOEO Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH)
BAT_SOC PID 52.5 52.6 52.6 53 %
scientia non olet · About Mike's Workshop Manuals