Anti-Lock Brake System - TEVES-Mark IV

• Description
• Operation
  • Notes
  • Pedal Feel Characteristics
• Bleeding Brake System
  • Notes
  • Manual Bleeding
  • Pressure Bleeding
  • Bleeding Hydraulic Control Unit
• Diagnosis & Testing
  • Self-Diagnostic System
    • Notes
    • Start-Up Cycle
    • Drive-Off Cycle
  • Diagnostic Procedure
    • Test Equipment Required
    • Diagnostic Procedure
  • System Precautions
  • DRB-II Test Functions
    • Notes
    • Entering DRB-II Main Menu
    • ABS Mode
    • VEHICLES TESTED Mode
    • HOW TO USE Mode
    • CONFIGURE Mode
    • DRB-II Volt/Ohmmeter Mode
    • DRB-II Continuity Meter Mode
  • DRB-II Problems & Error Messages
    • Blank Message Screen
    • RAM TEST FAILURE Message
    • CARTRIDGE ERROR Message
    • KEY PAD TEST FAILURE Message
    • HIGH BATTERY Or LOW BATTERY Message
  • Connector Identification
• Self-Diagnostic Tests
  • Notes
  • Visual Inspection
    • Notes
    • Hydraulic Control Unit
    • Power Distribution Center & Relays
    • Wheel Speed Sensors & Connectors
    • Brake Fluid Lines & Fittings
    • Controller Anti-Lock Brake (CAB)
  • Test 1A Checking System For Fault Messages
  • Test 2A Abs Amber Warning Lamp Circuit Failure
  • Test 2B Abs Amber Warning Lamp Circuit Failure
  • Test 3A Fluid Level Switch Open
  • Test 4A Fluid Level Switch Not Processable
  • Test 5A Hydraulic Failure
  • Test 6A Left Front Inlet Valve
  • Test 7A Left Front Outlet Valve
  • Test 8A Left Front Sensor Circuit Failure
  • Test 9A Correcting Left Front Sensor Faults
  • Test 10A Left Rear Inlet Valve
  • Test 11A Left Rear Outlet Valve
  • Test 12A Left Rear Sensor Circuit Failure
  • Test 13A Correcting Left Rear Sensor Faults
  • Test 14A Main Relay/Power Circuit Failure
  • Test 14B Main Relay/Power Circuit Failure
  • Test 14C Main Relay/Power Circuit Failure
  • Test 15A Pedal Travel Sensor Circuit
  • Test 16A Pressure Switch/Brake Switch Circuits
  • Test 16B Pressure Switch/Brake Switch Circuits
  • Test 17A Pump Motor Circuit Not Working Properly
  • Test 17B Pump Motor Circuit Not Working Properly
  • Test 17C Pump Motor Circuit Not Working Properly
  • Test 17D Pump Motor Circuit Not Working Properly
  • Test 18A Pump Motor Running Without Command
  • Test 19A Right Front Inlet Valve
  • Test 20A Right Front Outlet Valve
  • Test 21A Right Front Sensor Circuit Failure
  • Test 22A Correcting Right Front Sensor Faults
  • Test 23A Right Rear Inlet Valve
  • Test 24A Right Rear Outlet Valve
  • Test 25A Right Rear Sensor Circuit Failure
  • Test 26A Correcting Right Rear Sensor Faults
  • Test 27A Traction Control Valve #1
  • Test 28A Traction Control Valve #2
  • Test 29A Correcting Inoperative Low-Speed Traction Control System (LTCS)
  • Test 29B Correcting Inoperative Low-Speed Traction Control System (LTCS)
  • Test 30A Correcting Inoperative LTCS Green Active Lamp
  • Test 30B Correcting Inoperative LTCS Green Active Lamp
  • Test 31A Correcting Inoperative LTCS Amber Warning Lamp
  • Test 31B Correcting Inoperative LTCS Amber Warning Lamp
  • Test 32A Correcting Red Brake Warning Lamp That Stays On
  • Test 33A Correcting Abs Warning Lamp (Amber) That Does Not Glow At Start-Up
  • Test 34A Correcting DRB-II No Response Condition
  • VER-1A System Verification Test
• Removal & Installation
  • Notes
  • Hydraulic Control Unit
    • Removal
    • Installation
  • Hydraulic Control Unit Reservoir
    • Removal
    • Installation
  • Pump/Motor Assembly
  • Pedal Travel Sensor
    • Notes
    • Removal
    • Installation
  • Proportioning Valves
    • Notes
    • Removal & Installation
  • Controller Anti-Lock Brake (Cab)
    • Notes
    • Removal
    • Installation
  • Abs Relay & Pump/Motor Relay
    • Notes
    • Removal & Installation
  • Front Wheel Speed Sensor
    • Removal
    • Installation
  • Rear Wheel Speed Sensor
    • Removal
    • Installation
• Adjustments
  • Parking/Emergency Brake
  • Stoplight Switch Adjustment
• Torque Specifications
• Wiring Diagram