Fastener Specifications
WARNING: This page is about a different variant/trim than selected.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Charge Air Bypass Regulator Solenoid Valve Vacuum Tube Seal |
| Emission Reduction Fluid Injector Gasket |
| Emission Reduction Fluid Supply Pump Module Seal |
| Exhaust Front Pipe Gasket |
| Exhaust Gas Recirculation Cooler Housing Gasket |
| Exhaust Gas Recirculation Cooler Inlet Pipe Gasket |
| Exhaust Gas Recirculation Cooler Outlet Pipe Gasket |
| Exhaust Gas Recirculation Valve Gasket |
| Fuel Filter Assembly Cap Gasket |
| Fuel Injection Pump Metering Valve Seal Ring |
| Fuel Injection Pump Seal Ring |
| Fuel Injector Fuel Return Hose Clamp |
| Fuel Injector Washer |
| Fuel Pump Module Seal |
| Power Brake Booster Inlet Hose Connector Fitting Seal |
| Throttle Body Gasket |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Fuel Injection Fuel Feed Pipe - Fuel Injection Pump to Fuel Rail | 28N.m(21 lb ft) |
| Fuel Injection Fuel Feed Pipe Replacement - Fuel Rail to Fuel Injector | 28N.m(21 lb ft) |
| Fuel Injector Bracket Bolt | |
|
10N.m(89 lb in) |
|
60 degrees |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Accelerator Pedal Fastener | 6 N.m (53 lb in) |
| Air Cleaner Outlet Duct Clamp | 3.5 N.m (31 lb in) |
| Air Cleaner Upper Housing Bolt | 2.5 N.m (22 lb in) |
| Camshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Charge Air Bypass Regulator Solenoid Valve Vacuum Tube Bracket Bolt | 10 N.m (89 lb in) |
| Charge Air Temperature Sensor | 19 N.m (14 lb ft) |
| Crankshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Engine Control Module and Electronic Brake Control Module Bracket Bolt | 12 N.m (106 lb in) |
| Engine Control Module and Engine Wiring Harness Conduit Bolt | 9 N.m (80 lb in) |
| Emission Reduction Fluid Controller Bolt - Notchback | 5 N.m (44 lb in) |
| Emission Reduction Fluid Controller Bolt - Hatchback | 2.5 N.m (22 lb in) |
| Emission Reduction Fluid Injector Nut | 9 N.m (80 lb in) |
| Emission Reduction Fluid Tank Bolt | 22 N.m (16 lb ft) |
| Emission Reduction Fluid Tank Nut | 22 N.m (16 lb ft) |
| Emission Reduction Fluid Tank Opening Filler Bolt | 9 N.m (80 lb in) |
| Emission Reduction Fluid Tank Support Bracket Nut | 9 N.m (80 lb in) |
| Engine Coolant Fan Shroud Bolt | 5 N.m (44 lb in) |
| Engine Coolant Temperature Sensor | 33 N.m (24 lb ft) |
| Exhaust Front Pipe Nut | 22 N.m (16 lb ft) |
| Exhaust Gas Recirculation Cooler Housing Bolt | 25 N.m (18 lb ft) |
| Exhaust Gas Recirculation Cooler Outlet Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Gas Recirculation Cooler Temperature Sensor | 45 N.m (33 lb ft) |
| Exhaust Gas Recirculation Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Gas Recirculation Vacuum Regulator Solenoid Valve Bolt | 7 N.m (62 lb in) |
| Exhaust Manifold Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Muffler Hanger Bracket Nut | 22 N.m (16 lb ft) |
| Exhaust Muffler Insulator Nut | 22 N.m (16 lb ft) |
| Exhaust Muffler Nut | 22 N.m (16 lb ft) |
| Exhaust Muffler To Front Pipe Nut | 22 N.m (16 lb ft) |
| Exhaust Particulate Sensor | 45 N.m(33 lb ft) |
| Exhaust Particulate Sensor Fastener | 9 N.m(80 lb in) |
| Exhaust Pressure Differential Sensor Bolt | 9 N.m(80 lb in) |
| Exhaust Pressure Sensor Pipe Bolt | 10 N.m (89 lb in) |
| Exhaust Pressure Sensor Pipe Bracket Bolt | 10 N.m (89 lb in) |
| Exhaust Temperature Sensor | 45 N.m (33 lb ft) |
| Exhaust Temperature Sensor Electrical Connector Bracket Bolt | 9 N.m (80 lb in) |
| Fuel Filter Assembly Cap | 25 N.m (18 lb ft) |
| Fuel Injection Fuel Feed Pipe Bracket Bolt | 9 N.m (80 lb in) |
| Fuel Injection Pump Bolt | 25 N.m (18 lb ft) |
| Fuel Injection Pump Drive Pulley Nut | 64 N.m (47 lb ft) |
| Fuel Injection Pump Driven Sprocket Nut | 64 N.m (47 lb ft) |
| Fuel Injection Pump Metering Valve Bolt | 10 N.m (89 lb in) |
| Fuel Rail Bolt | 25 N.m (18 lb ft) |
| Fuel Tank Filler Hose Clamp-Fuel Tank | 2.5 N.m (22 lb in) |
| Fuel Tank Filler Hose Clamp-Filler Pipe | 3.5 N.m (31 lb in) |
| Fuel Tank Filler Pipe Bolt | 9 N.m (80 lb in) |
| Fuel Tank Filler Pipe Ground Bolt | 22 N.m (16 lb ft) |
| Fuel Tank Strap Bolt | 22 N.m (16 lb ft) |
| Glow Plug | 16.5 N.m (12 lb ft) |
| Intake Manifold Bolt | 12N.m (106 lb in) |
| Intake Manifold Brace Bolt | 10 N.m (89 lb in) |
| Mass Airflow Sensor Fastener | 2.5 N.m (22 lb in) |
| Nitrogen Oxides Sensor | 50 N.m (37 lb ft) |
| Nitrogen Oxides Sensor Control Module Nut | 9 N.m (80 lb in) |
| Oil Pump Flow Control Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Parking Brake Bolt | 22 N.m (16 lb ft) |
| Parking Brake Cable Nut | 9 N.m (80 lb in) |
| Piston Oil Nozzle Oil Control Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Power Brake Booster Inlet Hose Connector Fitting Bolt | 10 N.m (89 lb in) |
| Power Brake Booster Inlet Hose Connector Fitting Bracket Bolt | 10 N.m (89 lb in) |
| Radiator Surge Tank Outlet Hose Bracket Bolt | 10 N.m (89 lb in) |
| Throttle Body Bolt | 10 N.m (89 lb in) |
| Transmission Bolt | 58 N.m (43 lb ft) |
| Turbocharger Actuator Pipe Bracket Bolt | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Pipe Bolt | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Bolt | 10 N.m (89 lb in) |
| Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Bracket Bolt | 10 N.m (89 lb in) |
| Vacuum Bracket Line Bolt | 10 N.m (89 lb in) |