Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Chevrolet >> 2006 >> Chevy Express G2500, Van Cargo Extended, 6.0 U >> Repair and Diagnosis >> External Pages >> Different car >> Section 905 (Cellular System, Entertainment System, And Navigation System) >> Repair Instructions >> Antenna Cable Replacement >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2007 GMC Savana Special, 2007 GMC Savana Camper Special, 2007 GMC Savana, 2007 Chevrolet RV Cutaway, and 2007 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Antenna Mast & Components
    GM887173Courtesy of GENERAL MOTORS CORP.
  1. Install the fixed antenna cable/base (3).
    2. NOTE: Refer to FASTENER NOTICE .
  2. Install the antenna cable/base mounting bolts (4).

    Tighten:  Tighten the antenna cable/base mounting bolts (4) to 11 N.m (97 lb in).

  3. Route the antenna base cable under the A/C case and through the hole in the firewall.
  4. Install the antenna cable grommet (5) through firewall and seat the grommet (5).
  5. Install the antenna collar (2).
  6. Connect the antenna base cable to the antenna extension cable.
  7. Install the passenger side hinge pillar trim. Refer to Body Hinge Pillar Trim Panel Replacement .
  8. Install the antenna mast (1). Refer to Fixed Antenna Mast Replacement .
scientia non olet · About Mike's Workshop Manuals