Mike's Workshop Manuals: Service manuals for every vehicle
Home >> Chevrolet >> 1983 >> Forward Control 7.4 W, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 6 (Power Steering General Servicing) >> Lubrication >> Refilling & Bleeding System

Refilling & Bleeding System

WARNING: This page does not describe the selected car, but rather 110 other vehicles, including the 1987 GMC Vandura Special, 1987 GMC Vandura, 1987 GMC Value Van, 1987 GMC Suburban, and 1987 GMC Safari. However, it is still accessible from the selected car via links, so may be relevant.
  1. Fill reservoir to correct level. Let oil settle for 2 minutes. Start engine and run for 2 seconds. Check reservoir and add oil if necessary. Repeat procedure until level in reservoir remains constant after running engine.
  2. Raise front of vehicle so that both wheels are off ground. Start engine and increase engine speed to 1500 RPM. Turn wheels right and left, lightly contacting stops. Check fluid and add if necessary.
  3. Lower vehicle. Turn wheels right and left. Check fluid level and add if necessary. If oil is foamy, allow vehicle to stand for a few minutes with engine off.
  4. Repeat procedure with vehicle raised. Again check fluid level and for air in system. If level is low or there is air in system, repeat complete procedure.
scientia non olet · About Mike's Workshop Manuals