Fastener Specifications
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Air Conditioning System Sealing Washer |
| Air Conditioning O-Ring Seal |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Air Conditioning Compressor Bolt | 22 N.m (16 lb ft) |
| Air Conditioning Compressor Bracket Bolt | 22 N.m (16 lb ft) |
| Air Conditioning Compressor Clutch Coil Bracket Bolt | 6 N.m (53 lb in) |
| Air Conditioning Compressor Hose Nut | 22 N.m (16 lb ft) |
| Air Conditioning Compressor Hose Nut @ Camshaft Cover | 9 N.m (80 lb in) |
| Air Conditioning Compressor Nut | 22 N.m (16 lb ft) |
| Air Conditioning Compressor Pulley Bolt | 20.5 N.m (15 lb ft) |
| Air Conditioning Compressor Stud | 9 N.m (80 lb in) |
| Air Conditioning Condenser Tube Nut | 22 N.m (16 lb ft) |
| Air Conditioning Evaporator Thermal Expansion Valve Bolt | 4.7 N.m (42 lb in) |
| Air Conditioning Refrigerant Heat Exchanger Nut | 22 N.m (16 lb ft) |
| Air Conditioning Refrigerant Heat Exchanger Nut @ Front Compartment Side Rail | 9 N.m (80 lb in) |
| Air Conditioning Refrigerant Pressure Sensor | 7 N.m (62 lb in) |
| Blower Motor Bolt | 1.2 N.m (11 lb in) |
| Charge Port Cap | 1.3 N.m (12 lb in) |
| Engine Wiring Harness Bracket Bolt | 9 N.m (80 lb in) |
| Floor Front Air Outlet Duct Bolt | 1.5 N.m (13 lb in) |
| Floor Front Air Outlet Duct Bolt - Left Side | 2.5 N.m (22 lb in) |
| Floor Front Air Outlet Duct Bolt - Right Side | 1.5 N.m (13 lb in) |
| Front Floor Console Rear Air Duct Bolt | 2.5 N.m (22 lb in) |
| Heater and Air Conditioning Evaporator and Blower Module Nut | 9 N.m (80 lb in) |
| Heater and Air Conditioning Evaporator and Blower Module Screw | 2.5 N.m (22 lb in) |
| Heater and Air Conditioning Remote Control Bracket Screw | 2.5 N.m (22 lb in) |
| Heater Coolant Pump Bolt @ Engine | 9 N.m (80 lb in) |
| Heater Coolant Pump Bracket Bolt @ Engine | 22 N.m (16 lb ft) |
| Heater Coolant Pump Bracket Bolt @ Heater Water Auxiliary Pump Bracket | 9 N.m (80 lb in) |
| Heater Outlet Hose Bracket Bolt @ Heater Coolant Pump Hose | 22 N.m (16 lb ft) |
| Instrument Panel Center Air Outlet Duct Bolt @ Air Inlet Housing | 1.5 N.m (13 lb in) |
| Instrument Panel Center Air Outlet Duct Bolt @ Instrument Panel Tie Bar | 2.5 N.m (22 lb in) |
| Side Window Defogger Outlet Duct Bolt | 2.5 N.m (22 lb in) |
| Windshield Defroster Outlet Duct Bolt | 2.5 N.m (22 lb in) |